Water heaters
Ramadan Drain CleaningHeating element and thermostat in Sulaibikhat
Heating element and thermostat failures in Sulaibikhat stem from intense humidity and salt spray near the waterfront. Sulaibikhat is a residential area on the Gulf coast with flats and villas facing the sea, and the marine environment corrodes the heater's metal parts and electrical circuits.
Which part
Element, orthermostat.
These signs point at the part before anyone takes a cover off.
01
Warm but never hot
The element is still working but the heat is not reaching the water, because the sheath is wrapped in a scale layer that insulates it. The water feels tepid and never quite gets to a comfortable shower temperature however long you wait.
02
The temperature drifted
The tank used to give the same temperature at the same setting, and now it is colder or hotter with the dial untouched. The thermostat has drifted off its reading, and that is a part you replace rather than adjust.
03
A new element failed early
When an element burns out again soon after it was changed, the part itself is rarely the reason. A floor full of sediment or a thermostat that will not switch off will cook any new element, which is why both get checked with every replacement.
04
A weep at the flange
Water seeping around the plate after a change means the gasket is tired or was seated on a face that was not cleaned. This is not the tank leaking. A fresh gasket, a cleaned face and even tightening across the bolts settles it.
This area
What setsthis area apart
Villas and flats in Sulaibikhat sit very close to the sea, and salt in the air penetrates more heavily than anywhere else in Kuwait. Thermostats on heaters here corrode from saltiness even when voltage is good, and the element needs strong filtration because seawater-influenced supply carries extra minerals. The heater's wiring and terminals need thick insulation and protection from salty water, and even tiny leaks cause rapid corrosion. We inspect the insulation and protective covers around the thermostat and connections first, and flag any rust for immediate part replacement.
Sulaibikhat is in Kuwait governorate, a coastal residential district on the Gulf waterfront north of Hawalli near the North Ring Road.
Sulaibikhat heaters face salt spray and sea breeze, so the thermostat and element need extra corrosion protection compared to inland Kuwait units.
Parts at a glance
The two parts.
Service
Heater element and thermostat replacement
Parts
Element, thermostat, thermal cut out and flange gasket
Fits
Central cylinders and small wall heaters alike
Before fitting
We measure the old part and inspect the tank floor
Hours
Daily, 6:00 in the morning to 12:00 midnight
Fitting
How a part ischanged.
Four steps, and each one is there for a reason rather than out of habit.
We confirm the part
Before anything is undone we read the element, the thermostat and the cut out. The meter names the failed part, and some heaters come back with both of them gone.
We drop the water level
The element comes out of a flange on the body of the tank, so the water has to fall below it first. A thermostat is reached from outside and needs none of this.
We fit an element that matches
The replacement has to be the same length, the same power and the same connection as the one that came out, so it clears the tank floor and suits the circuit already there.
We tighten evenly and pressure test
A new gasket goes on, the bolts are tightened evenly and in turn, and the tank is filled so we can watch the flange under pressure before the power goes anywhere near it.
Common questions
Questions about Heating element and thermostat in Sulaibikhat
Green or reddish discolouration on wires or terminals around the thermostat signals rust. A soft crackling sound in the heater or repeated power cuts point to internal corrosion. If you spot any of these signs on your Sulaibikhat heater, call right away.
If the heater is over eight years old and the thermostat is heavily corroded, a new unit is more economical. Modern heaters in Sulaibikhat have better salt and moisture protection and last longer.
Other services
Other services in Sulaibikhat
Other work we do in the same area.
Back to Heating element and thermostat