Water heaters
Ramadan Drain CleaningHeating element and thermostat in Mansouriya
Heating element and thermostat in Mansouriya require separate electrical measurement because each has its own circuit. Mansouriya is a busy residential area in Kuwait with a mix of modern and older villas and flats, electric heaters are common, and faults can start with slow heating and progress to complete heat loss.
Which part
Element, orthermostat.
These signs point at the part before anyone takes a cover off.
01
Warm but never hot
The element is still working but the heat is not reaching the water, because the sheath is wrapped in a scale layer that insulates it. The water feels tepid and never quite gets to a comfortable shower temperature however long you wait.
02
The temperature drifted
The tank used to give the same temperature at the same setting, and now it is colder or hotter with the dial untouched. The thermostat has drifted off its reading, and that is a part you replace rather than adjust.
03
A new element failed early
When an element burns out again soon after it was changed, the part itself is rarely the reason. A floor full of sediment or a thermostat that will not switch off will cook any new element, which is why both get checked with every replacement.
04
A weep at the flange
Water seeping around the plate after a change means the gasket is tired or was seated on a face that was not cleaned. This is not the tank leaking. A fresh gasket, a cleaned face and even tightening across the bolts settles it.
This area
What setsthis area apart
Mansouriya has a mix of older villas, modern residential blocks and varied flats, with heaters in kitchens and bathrooms of different sizes and ages. Older Mansouriya villas and flats may have heating elements that have run for years and lost efficiency, so we measure current and voltage to tell if the element is still producing heat or has given up. The thermostat may also be worn from years of use, so we test it with an ohmmeter and confirm it cuts the circuit at the right temperature.
Mansouriya sits in Kuwait governorate, a busy residential area mixing villas, residential blocks and flats near the Fourth Ring Road.
Mansouriya heaters include both old and new elements, so electrical testing must account for the heater age.
Parts at a glance
The two parts.
Service
Heater element and thermostat replacement
Parts
Element, thermostat, thermal cut out and flange gasket
Fits
Central cylinders and small wall heaters alike
Before fitting
We measure the old part and inspect the tank floor
Hours
Daily, 6:00 in the morning to 12:00 midnight
Fitting
How a part ischanged.
Four steps, and each one is there for a reason rather than out of habit.
We confirm the part
Before anything is undone we read the element, the thermostat and the cut out. The meter names the failed part, and some heaters come back with both of them gone.
We drop the water level
The element comes out of a flange on the body of the tank, so the water has to fall below it first. A thermostat is reached from outside and needs none of this.
We fit an element that matches
The replacement has to be the same length, the same power and the same connection as the one that came out, so it clears the tank floor and suits the circuit already there.
We tighten evenly and pressure test
A new gasket goes on, the bolts are tightened evenly and in turn, and the tank is filled so we can watch the flange under pressure before the power goes anywhere near it.
Common questions
Questions about Heating element and thermostat in Mansouriya
A heating element cannot be repaired; if it stops heating it must be replaced. But before we replace it we verify the thermostat is signalling correctly, then we remove the old element and fit a new one.
Water comes out way too hot and never cools, or the heater will not run at all even though power is good. We test it with a meter to see if it opens and closes the circuit with temperature or has lost sensitivity.
Nearby areas
More areas for Heating element and thermostat
Same service, in nearby areas.
Other services
Other services in Mansouriya
Other work we do in the same area.
Back to Heating element and thermostat