Plumbing and sanitary
Ramadan Drain CleaningKitchen flue installation in Shuwaikh Industrial
Kitchen flue installation in Shuwaikh Industrial means handling canteen and restaurant kitchens inside factories and warehouses. Shuwaikh Industrial is an entire zone of factories, warehouses and logistics firms, with tall buildings and tangled wires and pipes across roofs. The flue here fights against long hours and heavy grease from industrial cooking.
Extraction symptoms
When the ductis the problem.
The hood runs loudly and the smell stays. That is where you start at the duct.
01
It runs and the smell stays
If the noise is strong but the air above the hob is not moving, the duct is either packed with grease, its outside termination is shut, or the hood was never ducted at all and is recirculating the air.
02
Steam gathering on the ceiling
Steam rising past the hood and collecting on the ceiling and the cupboards means the pull is weaker than the steam being produced. Usually the route is long, or it carries too many bends eating into the draw.
03
Grease dripping from the duct
Greasy drops coming off the joint above the hood mean grease has built up inside the duct, cooled and started to run back. That case needs the route cleaned, not just a new filter.
04
Outside air blows back in
Feeling hot air or dust coming in through the hood while it is off means the flap on the outside termination is broken or missing. That opening needs a flap that lifts with the extraction and falls shut after it.
This area
What setsthis area apart
Most factories and warehouses in Shuwaikh Industrial have small restaurants or worker canteens, and ducts run over roofs or within the building's outer frame for easy maintenance. Roofs are crowded with AC pipes and electrics, so the outlet sits cramped and needs clearance from other vents. Grease builds up faster here because the kitchen runs long hours daily, so the duct walls get thick after just weeks.
Shuwaikh Industrial sits in the Capital governorate, a zone of tightly packed factories, warehouses and logistics hubs.
Industrial kitchens in Shuwaikh produce more grease than domestic kitchens, so the ducts block much faster.
In short
The duct work.
Service
Kitchen flue and duct installation
Included
The duct route, joints, outside termination and its flap
Where it applies
Home and flat kitchens, and restaurant and shop kitchens
Harder cases
Flats with no outside wall, and long routes with bends
Hours
Daily, 6:00 in the morning to 12:00 midnight
How we route it
From the hood tothe outside wall.
The route is decided before a single component is bought.
We find the nearest way out
We work out the shortest route from the hood to the nearest outside wall or light well, because every extra length and every bend takes from the pull.
We size the duct
The duct is sized against the hood and the route. Narrowing it so it can pass behind a cupboard kills the draw, however strong the hood is.
We run it and seal the joints
The duct runs with as few bends as possible, and every joint is sealed so no steam or smell escapes into a false ceiling or behind the cupboards.
We fit the flap and test
The outside opening takes a flap that lifts with the extraction and closes after it, then the hood runs and we confirm the air above the hob really is moving.
Common questions
Questions about Kitchen flue installation in Shuwaikh Industrial
If the kitchen runs daily, the flue needs cleaning every two or three months. We check the thickness inside and tell you exactly.
No, the flue outlet must sit at a safe distance from any other vent opening. Hot greasy air will flow back in and block the AC pipes.
Nearby areas
More areas for Kitchen flue installation
Same service, in nearby areas.
Other services
Other services in Shuwaikh Industrial
Other work we do in the same area.
Back to Kitchen flue installation